Sea Ray 425 Sundancer Owner's Manual Page 180
- Page / 192
- Table of contents
- BOOKMARKS
Rated. / 5. Based on customer reviews
8.12
SECTION 8 • REQUIRED INSPECTION, SERVICE AND
MAINTENANCE
40 Sundancer
®
(425 Sundancer
®
)
QUICK REFERENCE CHECKLIST (CONT’D)
3. Ignition ..................................................................... Depress ENGINE STOP switches on the helm switch
panel when engines are cooled down.
4. Engine Operation .................................................... Check idle and shift. Listen for abnormal noises
E. SECURING THE BOAT
GENERAL
1. Shore Power Cable ................................................ Connected to dockside power inlet
2. Lines and Fenders .................................................. Fenders in place, lines tied securely to dock
BOAT SYSTEMS
1. Seacocks ................................................................ Closed (handle perpendicular to hose)
2. Helm Switch Panel ................................................. All switches in the OFF position
3. Gearshift & Throttle Controls .................................. In the NEUTRAL and IDLE positions
ENGINE
1. Ignition .................................................................... Switched in the OFF position (lights off) and master
ignition keys removed from DC distribution panel
2. Battery Switches ..................................................... In the OFF position
1. Fuel Valves (Diesel Only)....................................... Closed (handle perpendicular to hose)
F. I F THE ENGINE DOES NOT START
NO STARTER MOTOR RESPONSE
1. Check gearshift/throttle control levers in the NEUTRAL positions
2. Check battery condition for sufficient charge
3. Check battery cable connections tight and free from corrosion
4. Check battery switches in the ON position
5. Check starter motor and solenoid connections
6. Check ignition switch connections
STARTER MOTOR RESPONDS, BUT NO IGNITION
1. Check that fuel tanks are not empty
2. Check fuel filters and filter/water separators clean
3. Check electrical connections on engine wiring harness and ignition wiring
- 40 Sundancer 1
- INTRODUCTION 3
- ABOUT YOUR LIMITED WARRANTY 6
- (425 Sundancer 12
- SECTION 1 • SAFETY 13
- 1. DOCKING/LIFTING/STORAGE 35
- 2. PASSENGER LOCATIONS 36
- (FIG. 2.3.1) 37
- 4. PROPULSION SYSTEM 38
- 5. PROPELLERS 38
- 6. GENERAL DECK LAYOUT 39
- 7. CABIN LAYOUT 40
- 8. SPOILER 41
- (FIG. 2.8.1) 42
- . 2.9.1) 43
- (FIG. 2.10.1) 44
- CONTROL STATION SWITCH PANEL 44
- (DIESEL OPTION) 44
- (FIG. 2.10.2) 44
- (FIG. 2.11.1) 45
- PORT THROUGH-HULL FITTINGS 45
- (FIG. 2.11.2) 45
- BILGE THROUGH-HULL FITTINGS 46
- (FIG. 2.12.1) 46
- TRANSOM THROUGH-HULL FITTINGS 46
- (FIG. 2.12.2) 46
- 11. MAJOR CONTROLS 47
- C. HYDRAULIC TRIM TABS 48
- 12. IMPORTANT GAUGES 50
- C. SYNCHRONIZER 51
- Engine Shutdown 52
- Override System 52
- SEA-FIRE 52
- G. S YSTEMS MONITOR 53
- Function 55
- Description 55
- NAVIGATOR 56
- 14. CONSOLE DIMMER 57
- SWITCHES & RECEPTACLES 58
- (FIG. 2.24.1) 58
- SWITCH AND RECEPTACLE LAYOUT 59
- (FIG. 2.26.1) 60
- 16. LIGHTING LAYOUT 61
- LIGHTING LAYOUT 62
- SECTION 3 • USING YOUR BOAT 63
- 1. BILGE 81
- 2. BILGE PUMPS 81
- 3. BILGE BLOWERS 82
- 4. ENGINES 83
- 5. ENGINE GAUGE PACKAGE 83
- 8. MARINE GEARS 84
- 9. ENGINE EXHAUST SYSTEM 84
- 6. FRESH WATER COOLING SYSTEM 84
- 7. ENGINE MOUNTS 84
- 10. ENGINE REMOVAL 85
- 11. VIBRATION & CAUSES 85
- D. COUPLING OUT OF TRUE 86
- F. O THER POSSIBLE CAUSES 86
- 13. UNDERWATER GEAR 87
- B. SHAFTS 90
- C. CARRIER SEAL KIT 90
- D. STRUT 91
- 15. SEACOCKS & STRAINERS 92
- 16. HYDRAULIC POWER STEERING 93
- 17. ELECTRIC BILGE HATCH 93
- 18. 40 DA BILGE LAYOUT 94
- 40 DA BILGE LAYOUT (DIESEL) 95
- SECTION 5 • FUEL SYSTEM 100
- SECTION 6 • ELECTRICAL SYSTEM 103
- Engines 27 12 600 155 4 103
- Bow Thruster 31 12 800 200 2 103
- ECTION 6 • ELECTRICAL SYSTEM 112
- 2. CARBON MONOXIDE MONITORS 149
- 1. LAYOUT AND ACCESSORIES 149
- 4. WATER SYSTEM 150
- A. WATER TANK 151
- B. WATER PUMPS & FILTER 152
- E. WATER HEATER 153
- ! WARNING 153
- F. DOCKSIDE WATER INLET 154
- G. C OCKPIT SHOWER 154
- H. GRAY WATER SUMP 154
- 5. HEAD SYSTEM 155
- B. VACU-FLUSH 156
- ! CAUTION 156
- 6. MACERATOR DISCHARGE PUMP 157
- SEACOCK INTERLOCK SYSTEM 157
- (OPTIONAL) 157
- 7. COMMUNICATION SYSTEM 158
- 8. ENTERTAINMENT CENTERS 159
- (FIG. 7.12.2) 160
- AUTOMATIC FIRE EXTINGUISHER 160
- (FIG. 7.12.1) 160
- C. HAND HELD EXTINGUISHERS 161
- 10. BOW THRUSTER (OPTIONAL) 162
- 11. REFRIGERATOR/FREEZER 162
- 12. COFFEE MAKER 162
- 13. STOVE & MICROWAVE 163
- 14. POWER VENTILATION SYSTEM 163
- 15. CENTRAL VACUUM (OPTIONAL) 163
- 16. HORN 163
- 17. CONVERTIBLE SOFAS 164
- 18. PRIVACY CURTAIN 164
- 19. SHORE POWER 164
- 20. WINDSHIELD VENT 164
- 21. CANVAS 164
- B. STORAGE: 165
- C. INSTALLATION TIPS: 165
- 22. FLOOR PLAN 166
- FLOOR PLAN 167
- (425 Sundancer 168
- MAINTENANCE 169
- 3. FIBERGLASS & GELCOAT 185
- SUBSTANCES 185
- 6. CARE FOR BOTTOM PAINT 186
- 5. PERMANENTLY MOORED OR 186
- DOCKED BOATS 186
- 4. STAINS & SCRATCHES 186
- 7. BILGE/ENGINE COMPARTMENT 187
- 8. TOPSIDE AREAS 187
- 9. GAUGE & SWITCH PANELS 187
- 10. ACRYLIC PLASTIC SHEETING 188
- (PLASTIC GLASS) 188
- 11. CANVAS AND CLEAR VINYL 188
Related products and manuals for Engine Sea Ray 425 Sundancer
Engine Sea Ray 175 Sport Owner's Manual
(89 pages)
(89 pages)
Engine Sea Ray 310 Sundancer User Manual
(137 pages)
(137 pages)
Engine Sea Ray 205 Sport Owner's Manual
(52 pages)
(52 pages)
Engine Sea Ray 300 Select Ex User Manual
(35 pages)
(35 pages)
Engine Sea Ray 300 Select Ex User Manual
(30 pages)
(30 pages)
© 2020, manymanuals.com. All rights reserved. | 3.442 s |
Manymanuals.com
Manymanuals.de
Manymanuals.fr
Manymanuals.it
Manymanuals.pl
Manymanuals.cz
Manymanuals.es
Manymanuals-pt.com
Comments to this Manuals